Samsung Fridge Warm or Frosting Over? Evaporator Cover DA97-13757A – Fix Airflow Failure Fast
Excessive frost buildup on the evaporator coils and a warm fresh food compartment are the most common signs that the evaporator cover assembly in your Samsung French Door refrigerator has failed or warped. In most Samsung RF-series refrigerators, the evaporator cover directs cold air from the evaporator coils through the compartment and prevents warm air from reaching the coils directly. When it cracks, warps, or loses its seal, airflow becomes uneven — the fridge warms up, frost accumulates on the coils, and the defrost cycle can no longer keep up. ⚡ Common failure point in Samsung RF28, RF30, and RF31 series French Door refrigerators. Part DA97-13757A is the genuine OEM evaporator cover assembly that restores proper airflow, eliminates frost buildup, and returns your refrigerator to factory cooling performance.
❓ Is This the Right Part?
This is the correct fix if ALL of the following are true:
- ✔ Refrigerator powers on and compressor runs normally
- ✔ Freezer compartment is maintaining temperature
- ✔ Defrost heater and defrost thermostat have been tested and confirmed functional
- ✔ ONLY problem is frost buildup on evaporator coils, warm fresh food section, or restricted airflow
Not sure? Send us your model number — we'll confirm before you order.
🔧 Common Symptoms
- Fresh food compartment is warm while freezer stays cold
- Heavy frost or ice buildup visible on evaporator coils behind the back panel
- Refrigerator runs constantly but cannot maintain set temperature
- Unusual fan noise — evaporator fan hitting ice buildup
✔ If these symptoms match, this is the most likely failed component in the cooling system.
✔ In most cases, replacing this evaporator cover restores proper airflow and eliminates frost accumulation immediately.
📦 Part Details
- Part Number: DA97-13757A
- Type: Refrigerator Evaporator Cover Assembly — directs airflow from evaporator coils through fresh food and freezer compartments
- Replaces: DA97-13757A (OEM direct replacement)
- Brands: Samsung
While the evaporator cover is off, test the defrost heater (DA47-00244C) and defrost thermostat for continuity. A failed defrost component is often the root cause of the frost buildup that warped or cracked the cover — replacing only the cover without addressing the defrost system will result in repeat failure.
⚙️ Installation
Skill Level: Moderate — 45–60 minutes. Disconnect power before servicing. Remove all food and shelving from the fresh food compartment, then unscrew the rear back panel to access the evaporator assembly. Disconnect any wiring harness clips attached to the cover, remove the old cover, and seat the new DA97-13757A into position. Reconnect wiring, reinstall the back panel, and allow the refrigerator to run for 24 hours to confirm stable temperatures.
✓ Compatible Models
Confirmed compatible with RF23HSESBSR/AA, RF24FSEDBSR/AA, RF25HMEDBBC/AA, RF25HMEDBSR/AA, RF25HMEDBWW/AA, RF28HMEDBBC/AA, RF28HMEDBSR/AA, RF28HMEDBWW/AA, RF28HMELBSR/AA, RF30HBEDBSR/AA, RF30KMEDBSG/AA, RF30KMEDBSR/AA, RF31FMEDBBC/AA, RF31FMEDBSR/AA, RF31FMEDBWW/AA, RF31FMESBSR/AA plus additional Samsung French Door models. Contact us to verify your model number before ordering.
💡 Pro Tip
Before replacing the evaporator cover, manually initiate a forced defrost cycle (hold Power Freeze + Fridge buttons for 8 seconds on most RF-series models). If the frost clears and temperatures recover, the defrost system is working and the cover itself is the culprit. If frost returns within 24 hours, the defrost heater or thermostat needs to be replaced alongside the cover.
✓ Model-Specific Repair Pages
✅Compatibility & Cross Reference
Not sure about your model number? Call 1-877-899-7278 and we’ll help you confirm. All brand names are the property of their respective owners and are used for compatibility reference only.
Buy Online Pick Up In-Store
Kitchener, Ontario N2E 1W8
- Choosing a selection results in a full page refresh.
